To those who know about the chain in a Jeep 231 transfer case putting a hole in the cover!!
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer case putting a hole in the cover!!
"Peter Parker" <nospam@zero.com> wrote in message
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer case putting a hole in the cover!!
"Peter Parker" <nospam@zero.com> wrote in message
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer case putting a hole in the cover!!
"Peter Parker" <nospam@zero.com> wrote in message
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
news:3f8ac868_2@nntp2.nac.net...
> In article <2621efad.0310122130.4a838c58@posting.google.com >,
--snip--
>
> Too bad. What were the symptoms before the TC opened up and
> dumped the fluid? I'm asking because I have 190800 on my YJ
> NP231 TC and the only thing I notice is that is sounds like it
> whines a little at highway speeds and stops when I let off the gas.
> Anyone know if this is a stretched TC chain wanting to open the case?
Afaik, the chain is not under load and therefore not susceptible to (much)
stretching except when four wheel drive is being used. On a YJ with that
strange front axle disconnect, the chain might not even be moving in two
wheel drive.
Earle
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
Usually a noise that lessens when you let up on the gas, is the
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
Usually a noise that lessens when you let up on the gas, is the
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
Usually a noise that lessens when you let up on the gas, is the
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
worn ring and pinion, in your rear differential.
God Bless America, ßill O|||||||O
mailto:-------------------- http://www.----------.com/
Peter Parker wrote:
>
> Too bad. What were the symptoms before the TC opened up and dumped
> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
> the only thing I notice is that is sounds like it whines a little
> at highway speeds and stops when I let off the gas. Anyone know if
> this is a stretched TC chain wanting to open the case?
>
> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
> >mi.
> >It runs very well, aside from an obvious transfer case problem because
> >it makes lots of noise. The transfer case has a hole on the bottom of
> >it and won't hold fluid.
>
> Did you buy it this way or did it make a "lot" of noise or just a
> whine when you were on the highway?
>
> >After taking off the cover, I've found that the chain inside has
> >stretched out to the point where it has been rubbing on the side and
> >has worn the hole through. I dropped the cover and gear and chain off
>
> I would imagine this would sound like what my current YJ has but it
> doesn't sound like it's wearing through the case. I think that would
> be felt and heard too. Much louder than a whine?
>
> >
> >Have you heard of this problem before, and could this chain stretching
> >possibly be preliminary enough to catch before the whole unit being
> >blown or ruined?
>
> I would like to know the same before it happens to me. Any peticular
> noise? Is it that highway whine when on the gas pedal and then when
> just coasting it goes away? It doesn't sound very loud but it sounds
> more like the rear.
>
> >Thanks in advance to any valuable advice. It will be very much
> >appreciated.
>
> Same here...
>
> --
> <html><form><input type crash></form></html>
> nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
In article <3F8AD857.FFF5EF1E@***.net>,
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
In article <3F8AD857.FFF5EF1E@***.net>,
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer caseputting a hole in the cover!!
In article <3F8AD857.FFF5EF1E@***.net>,
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
L.W.(=?iso-8859-1?Q?=DFill?=) ------ III <----------@***.net> wrote:
> Usually a noise that lessens when you let up on the gas, is the
>worn ring and pinion, in your rear differential.
Okay. My noise sounds and feels like it is coming from the rear. It's
not as bad as I thought and it's about the same when letting up on
the gas. It just changes down and sounds pretty normal IMHO. With
a 190K miles normal sounding. :)
> God Bless America, ßill O|||||||O
>mailto:-------------------- http://www.----------.com/
>
>Peter Parker wrote:
>>
>> Too bad. What were the symptoms before the TC opened up and dumped
>> the fluid? I'm asking because I have 190800 on my YJ NP231 TC and
>> the only thing I notice is that is sounds like it whines a little
>> at highway speeds and stops when I let off the gas. Anyone know if
>> this is a stretched TC chain wanting to open the case?
>>
>> >I just bought a nice 5-speed, 2-door, 96 cherokee, with about 150,000
>> >mi.
>> >It runs very well, aside from an obvious transfer case problem because
>> >it makes lots of noise. The transfer case has a hole on the bottom of
>> >it and won't hold fluid.
>>
>> Did you buy it this way or did it make a "lot" of noise or just a
>> whine when you were on the highway?
>>
>> >After taking off the cover, I've found that the chain inside has
>> >stretched out to the point where it has been rubbing on the side and
>> >has worn the hole through. I dropped the cover and gear and chain off
>>
>> I would imagine this would sound like what my current YJ has but it
>> doesn't sound like it's wearing through the case. I think that would
>> be felt and heard too. Much louder than a whine?
>>
>> >
>> >Have you heard of this problem before, and could this chain stretching
>> >possibly be preliminary enough to catch before the whole unit being
>> >blown or ruined?
>>
>> I would like to know the same before it happens to me. Any peticular
>> noise? Is it that highway whine when on the gas pedal and then when
>> just coasting it goes away? It doesn't sound very loud but it sounds
>> more like the rear.
>>
>> >Thanks in advance to any valuable advice. It will be very much
>> >appreciated.
>>
>> Same here...
>>
>> --
>> <html><form><input type crash></form></html>
>> nospam@zero.com Replace nospam with jetta to reply via e-mail
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
Guest
Posts: n/a
Re: To those who know about the chain in a Jeep 231 transfer case putting a hole in the cover!!
In article <bmek2k$le37n$1@ID-147790.news.uni-berlin.de>,
Earle Horton <enfermero_diabolico@registerednurses.com> wrote:
>"Peter Parker" <nospam@zero.com> wrote in message
>news:3f8ac868_2@nntp2.nac.net...
>> In article <2621efad.0310122130.4a838c58@posting.google.com >,
>--snip--
>>
>> Too bad. What were the symptoms before the TC opened up and
>> dumped the fluid? I'm asking because I have 190800 on my YJ
>> NP231 TC and the only thing I notice is that is sounds like it
>> whines a little at highway speeds and stops when I let off the gas.
>> Anyone know if this is a stretched TC chain wanting to open the case?
>
>Afaik, the chain is not under load and therefore not susceptible to (much)
>stretching except when four wheel drive is being used. On a YJ with that
>strange front axle disconnect, the chain might not even be moving in two
>wheel drive.
Oh Okay. I guess mine should be okay and what I am hearing is just a
worn ring and pinion.
Thanks.
>
>Earle
>
>
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail
Earle Horton <enfermero_diabolico@registerednurses.com> wrote:
>"Peter Parker" <nospam@zero.com> wrote in message
>news:3f8ac868_2@nntp2.nac.net...
>> In article <2621efad.0310122130.4a838c58@posting.google.com >,
>--snip--
>>
>> Too bad. What were the symptoms before the TC opened up and
>> dumped the fluid? I'm asking because I have 190800 on my YJ
>> NP231 TC and the only thing I notice is that is sounds like it
>> whines a little at highway speeds and stops when I let off the gas.
>> Anyone know if this is a stretched TC chain wanting to open the case?
>
>Afaik, the chain is not under load and therefore not susceptible to (much)
>stretching except when four wheel drive is being used. On a YJ with that
>strange front axle disconnect, the chain might not even be moving in two
>wheel drive.
Oh Okay. I guess mine should be okay and what I am hearing is just a
worn ring and pinion.
Thanks.
>
>Earle
>
>
--
<html><form><input type crash></form></html>
nospam@zero.com Replace nospam with jetta to reply via e-mail