Rough idle when hot
#11
Guest
Posts: n/a
Re: Rough idle when hot
I used to plug up the filter on my canister almost every time I went to
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
#12
Guest
Posts: n/a
Re: Rough idle when hot
I used to plug up the filter on my canister almost every time I went to
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
#13
Guest
Posts: n/a
Re: Rough idle when hot
I used to plug up the filter on my canister almost every time I went to
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
'play' in the local mud pit. There were many trips home with the gas
cap cracked open so it would run at speed.
I then moved the canister up under the brake booster so the tires
couldn't fill it up with mud any more.
If you drive on muddy or even dusty roads, that filter will plug up.
Other than that, I don't know the system you have so can't help.
Mike
Michael White wrote:
>
> Mike,
>
> Are you referring to the one in the Charcoal cannister? If so, that whole
> setup when in about two years ago. The air filter (K&N from the Mopar kit)
> I cleaned a few weeks ago. Is there another filter I should check?
>
> Thanks.
> --
> Michael White "To protect people from the effects of folly is to
> fill the world with fools." -Herbert Spencer, 1891
>
> Mike Romain (romainm@sympatico.ca) wrote on Wednesday 29 September 2004
> 08:59 am:
>
> > When was the last time you changed the air filter on the gas tank vent?
> > A vacuum on the gas tank can sort of act like that.
> >
> > Mike
> > 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> > 88 Cherokee 235 BFG AT's
> >
> > Michael White wrote:
> >>
> >> Hi all,
> >>
> >> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
> >> with
> >> a '94 Wrangler can help out too :). On my way back from a very long road
> >> trip, it started running rough every once in a while. This is while I
> >> was
> >> going about 70 MPH down I-20. I made it back without incident, but it's
> >> been getting progressively worse. Now, after running for about 5-10
> >> minutes (cold or hot), it'll start to miss, then backfire, then finally
> >> the
> >> engine will die. I can re-start it in a few minutes and run for a while
> >> again, but will soon start to miss, backfire, then die.
> >>
> >> The engine and fuel injection kit have been in for about two years now,
> >> and
> >> were running OK up to this point. I thought I might have picked up a bad
> >> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
> >> replaced the fuel filter - neither had any effect, positive or negative.
> >> I also went back to slightly hotter spark plugs I used just before I left
> >> on the road trip, which also had no effect.
> >>
> >> Any hints on how to solve this (or where to begin) would be greatly
> >> appreciated.
> >>
> >> Thanks in advance.
> >> --
> >> Michael White "To protect people from the effects of folly is to
> >> fill the world with fools." -Herbert Spencer, 1891
#14
Guest
Posts: n/a
Re: Rough idle when hot
Bill,
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
#15
Guest
Posts: n/a
Re: Rough idle when hot
Bill,
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
#16
Guest
Posts: n/a
Re: Rough idle when hot
Bill,
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
Thanks. Your suggestion set me on the right path. Turned out to be a bad
fuel injector. After eliminating the ignition coil, then the other
ignition components, I listened to each fuel injector with a 3/8"
extension. Five of my injectors make a nice periodic tick
(tick.....tick.....tick.....), while one sounded like it was about ready to
have a heart attack (ticktickticktick..ticktitickticktick..tick...tick ).
Hopefully, that's it. That would explain the backfiring, as fuel is being
continually dumped into the chamber, and the rough idle, as that injector
was taking fuel from the fuel rail when it shouldn't, starving the other
injectors.
I've had injectors fail on Nissans before, but never like that (always fail
dead) and never that soon (the Jeep's are less than two years old).
Chrysler quality?
Thanks again.
--
Michael White "To protect people from the effects of folly is to
fill the world with fools." -Herbert Spencer, 1891
L.W.(ßill) ------ III (----------@***.net) wrote on Tuesday 28 September
2004 09:23 pm:
> Hi Michael,
> Replace the ignition coil.
> God Bless America, ßill O|||||||O
> mailto:-------------------- http://www.----------.com/
>
> Michael White wrote:
>>
>> Hi all,
>>
>> I've got an '82 Scrambler with the Mopar fuel injection kit (so anyone
>> with
>> a '94 Wrangler can help out too :). On my way back from a very long road
>> trip, it started running rough every once in a while. This is while I
>> was
>> going about 70 MPH down I-20. I made it back without incident, but it's
>> been getting progressively worse. Now, after running for about 5-10
>> minutes (cold or hot), it'll start to miss, then backfire, then finally
>> the
>> engine will die. I can re-start it in a few minutes and run for a while
>> again, but will soon start to miss, backfire, then die.
>>
>> The engine and fuel injection kit have been in for about two years now,
>> and
>> were running OK up to this point. I thought I might have picked up a bad
>> batch of gas, so dumped in some "Sea Foam" to absorb any water, and
>> replaced the fuel filter - neither had any effect, positive or negative.
>> I also went back to slightly hotter spark plugs I used just before I left
>> on the road trip, which also had no effect.
>>
>> Any hints on how to solve this (or where to begin) would be greatly
>> appreciated.
>>
>> Thanks in advance.
Thread
Thread Starter
Forum
Replies
Last Post
jeep videos
Jeep Videos - Pictures
0
03-20-2008 02:29 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)