"REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline Six Cylinder
Guest
Posts: n/a
"REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline Six Cylinder
First and foremost, I would like to Thank everyone who took the time to
help me troubleshoot and guide me in the right direction in fixing my
Wagoneer. This group is a good thing and its members are good people. I
very much appreciated your input, THANK YOU!!!
After replacing the fuel filter the engine would not stay running. It
would start ok, but die after thirty or so seconds. We could here the
fuel pump engage when we turned the key, so we took it as the pump
being good. The pressure indicated something was wrong down there so we
took the pump out. The line inside the tank was degraded, probably just
for so many years in the tank. We replaced the fuel pump, strainer and
line. The wagoneer started right up and runs like new.
Two problems though, First the new fuel pump is loud. You can here it
inside and outside of the vehicle. The pump is Carter part # P74155. We
are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
But would the M.P.I. pump be able to fit if it was the wrong pump?
Second, when the new pump was put in, we must have screwed up something
because the tank reads empty and its full and the low fuel fuel light
is on all the time now. Yes I know we should of been more
careful----how to fix it is my question.
help me troubleshoot and guide me in the right direction in fixing my
Wagoneer. This group is a good thing and its members are good people. I
very much appreciated your input, THANK YOU!!!
After replacing the fuel filter the engine would not stay running. It
would start ok, but die after thirty or so seconds. We could here the
fuel pump engage when we turned the key, so we took it as the pump
being good. The pressure indicated something was wrong down there so we
took the pump out. The line inside the tank was degraded, probably just
for so many years in the tank. We replaced the fuel pump, strainer and
line. The wagoneer started right up and runs like new.
Two problems though, First the new fuel pump is loud. You can here it
inside and outside of the vehicle. The pump is Carter part # P74155. We
are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
But would the M.P.I. pump be able to fit if it was the wrong pump?
Second, when the new pump was put in, we must have screwed up something
because the tank reads empty and its full and the low fuel fuel light
is on all the time now. Yes I know we should of been more
careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
I only know that some of the fuel pumps, like our 88's runs on a ballast
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
I only know that some of the fuel pumps, like our 88's runs on a ballast
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
I only know that some of the fuel pumps, like our 88's runs on a ballast
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
resistor located near the rad on the drivers side fender. This is to
cut the noise down.
Maybe yours needs or doesn't need it?
The fact that the wiring isn't working properly would be a concern to
me. I don't 'think' the pump can run if the wires in the plug are
wrong, but if it is stealing 12 volts from the other circuit??....
I have just seen 2 DC mini vans with screwed pump wiring. One was a
Voyager and the other was a Caravan and the pumps that came for them
'were' wired wrong. I had to show both owners how to flip the wiring
around and one even had to have the ground modified.
Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Aug./05 http://www.imagestation.com/album/in...?id=2120343242
(More Off Road album links at bottom of the view page)
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
Sounds like your problem is the fuel filter, to begin with. follow
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
Sounds like your problem is the fuel filter, to begin with. follow
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Guest
Posts: n/a
Re: "REVISED"-----1987 Wagoneer Limited 4x4 Fuel Injected Inline SixCylinder
Sounds like your problem is the fuel filter, to begin with. follow
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
the fuel lines until your find the shield hiding it. Sorry about having
to take the pump back out to stick the float back in correctly.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
Johnny641 wrote:
>
> First and foremost, I would like to Thank everyone who took the time to
> help me troubleshoot and guide me in the right direction in fixing my
> Wagoneer. This group is a good thing and its members are good people. I
> very much appreciated your input, THANK YOU!!!
>
> After replacing the fuel filter the engine would not stay running. It
> would start ok, but die after thirty or so seconds. We could here the
> fuel pump engage when we turned the key, so we took it as the pump
> being good. The pressure indicated something was wrong down there so we
> took the pump out. The line inside the tank was degraded, probably just
> for so many years in the tank. We replaced the fuel pump, strainer and
> line. The wagoneer started right up and runs like new.
>
> Two problems though, First the new fuel pump is loud. You can here it
> inside and outside of the vehicle. The pump is Carter part # P74155. We
> are thinking they gave us the M.P.I. pump instead of the T.B.I. pump.
> But would the M.P.I. pump be able to fit if it was the wrong pump?
>
> Second, when the new pump was put in, we must have screwed up something
> because the tank reads empty and its full and the low fuel fuel light
> is on all the time now. Yes I know we should of been more
> careful----how to fix it is my question.
Thread
Thread Starter
Forum
Replies
Last Post
oscarpro
Jeep Cherokee Forum
0
Aug 5, 2012 02:33 PM
Johnny641
Jeep Mailing List
48
Nov 27, 2005 10:56 AM
CJ7 Casey
Jeep Mailing List
111
Feb 24, 2005 05:45 PM
L.W.(=?iso-8859-1?Q?=DFill?=) Hughes III
Jeep Mailing List
4
Sep 19, 2003 05:21 PM
Jeff Strickland
Jeep Mailing List
0
Sep 19, 2003 04:37 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
