97 TJ Overheating (manual trans)
05-22-2006, 05:34 AM
#1
Guest
Posts: n/a
97 TJ Overheating (manual trans)
When I drive in the city, the temp stays near 210F (midway, where it's
supposed to be).
However, highway driving (sustained 75mph) causes the temp to rise to
the point where I can't drive for more than 10 mins.
Dunno if this is a cooling problem or something awry with the fuel/air
mixture.
Also, I've noticed that Jeep water pumps only seem to last 90K miles,
and I'm close to 260K miles now. So I'm wondering if it's simply that
it's time to replace the pump. And if that's the case, then would a
FlowKooler high flow pump be any better than a stock pump? Even if not,
I hope that it atleast lasts longer.
Any suggestions?
supposed to be).
However, highway driving (sustained 75mph) causes the temp to rise to
the point where I can't drive for more than 10 mins.
Dunno if this is a cooling problem or something awry with the fuel/air
mixture.
Also, I've noticed that Jeep water pumps only seem to last 90K miles,
and I'm close to 260K miles now. So I'm wondering if it's simply that
it's time to replace the pump. And if that's the case, then would a
FlowKooler high flow pump be any better than a stock pump? Even if not,
I hope that it atleast lasts longer.
Any suggestions?
05-22-2006, 10:22 AM
#2
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
Radiator veins may be clogged with sediment, if your coolant wasn't
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
05-22-2006, 10:22 AM
#3
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
Radiator veins may be clogged with sediment, if your coolant wasn't
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
05-22-2006, 10:22 AM
#4
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
Radiator veins may be clogged with sediment, if your coolant wasn't
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
changed every two years.
God Bless America, Bill O|||||||O
mailto:-------------------- http://www.----------.com/
mrbogus@eim.ae wrote:
>
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
> Any suggestions?
05-22-2006, 10:36 AM
#5
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
What generally wears out first in an automotive water pump is the seal,
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
05-22-2006, 10:36 AM
#6
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
What generally wears out first in an automotive water pump is the seal,
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
05-22-2006, 10:36 AM
#7
Guest
Posts: n/a
Re: 97 TJ Overheating (manual trans)
What generally wears out first in an automotive water pump is the seal,
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
followed closely by the bearing. Sometimes, the bearing goes first. I
don't see how a FlowKooler high flow pump would help, unless they use
superior seals and bearings. What does their advertising say in this
regard? You should also suspect your fan clutch. When the engine is hot,
shut it off, open the hood, and see if the fan spins freely. If so, there
is your problem.
Water pumps don't usually show failure by poor performance, except in the
case where the impeller has been corroded. Possible, but unlikely unless
you have been pouring poor quality water into the system. I know you
wouldn't do that. ;^)
Earle
<mrbogus@eim.ae> wrote in message
news:1148290461.520336.119750@j33g2000cwa.googlegr oups.com...
> When I drive in the city, the temp stays near 210F (midway, where it's
> supposed to be).
>
> However, highway driving (sustained 75mph) causes the temp to rise to
> the point where I can't drive for more than 10 mins.
>
> Dunno if this is a cooling problem or something awry with the fuel/air
> mixture.
>
> Also, I've noticed that Jeep water pumps only seem to last 90K miles,
> and I'm close to 260K miles now. So I'm wondering if it's simply that
> it's time to replace the pump. And if that's the case, then would a
> FlowKooler high flow pump be any better than a stock pump? Even if not,
> I hope that it atleast lasts longer.
>
>
> Any suggestions?
>
*** Posted via a free Usenet account from http://www.teranews.com ***
Thread
Thread Starter
Forum
Replies
Last Post
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
