96 GC suddenly lost AC cooling
08-30-2004, 09:11 PM
#1
Guest
Posts: n/a
96 GC suddenly lost AC cooling
Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
condenser turns on and off, low pressure line is very cold and condensation
forms on the line. Air coming thru vents might have a higher humidity level
when the AC is turned on than when it is off.
Towed a 2500lb trailer last week for the first time, 400 miles thru the
hills of Pennsylvania and AC was working fine.
Any ideas? just turned 100K miles last week.
condenser turns on and off, low pressure line is very cold and condensation
forms on the line. Air coming thru vents might have a higher humidity level
when the AC is turned on than when it is off.
Towed a 2500lb trailer last week for the first time, 400 miles thru the
hills of Pennsylvania and AC was working fine.
Any ideas? just turned 100K miles last week.
08-30-2004, 09:35 PM
#2
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Hikers did pass the time by typing:
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
08-30-2004, 09:35 PM
#3
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Hikers did pass the time by typing:
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
08-30-2004, 09:35 PM
#4
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Hikers did pass the time by typing:
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and condensation
> forms on the line. Air coming thru vents might have a higher humidity level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
If the compressor cycles properly my first thought is vac leak.
Clicking on/off real rapididly means you could be low on 134a.
Is it an auto or manual AC system? The auto has diagnositcs and
doesn't use vac for much. The maunal uses vac for almost everything
except the blend air door.
Does it blow well? If not you might have mold buildup clogging the coil.
I don't have the specifics for the 96 but it should be similar in layout
to the 93.
--
-- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
Banks Header - and BEER, in the fridge!
08-31-2004, 03:52 PM
#5
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
"Hikers" <hikers@eclipse.net> wrote in message
news:4133d051$0$67726$ad3619e8@news.netcarrier.net ...
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and
condensation
> forms on the line. Air coming thru vents might have a higher humidity
level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
>
>
I had the same problem with my 95 ZJ and had to replace the orifice tube.
If you need one, I have a spare I would like to sell.
Mike
08-31-2004, 03:52 PM
#6
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
"Hikers" <hikers@eclipse.net> wrote in message
news:4133d051$0$67726$ad3619e8@news.netcarrier.net ...
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and
condensation
> forms on the line. Air coming thru vents might have a higher humidity
level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
>
>
I had the same problem with my 95 ZJ and had to replace the orifice tube.
If you need one, I have a spare I would like to sell.
Mike
08-31-2004, 03:52 PM
#7
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
"Hikers" <hikers@eclipse.net> wrote in message
news:4133d051$0$67726$ad3619e8@news.netcarrier.net ...
> Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> condenser turns on and off, low pressure line is very cold and
condensation
> forms on the line. Air coming thru vents might have a higher humidity
level
> when the AC is turned on than when it is off.
> Towed a 2500lb trailer last week for the first time, 400 miles thru the
> hills of Pennsylvania and AC was working fine.
> Any ideas? just turned 100K miles last week.
>
>
I had the same problem with my 95 ZJ and had to replace the orifice tube.
If you need one, I have a spare I would like to sell.
Mike
09-02-2004, 08:43 PM
#8
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Thanks DougW. Checked out your LED turn signal add ons on you site, Nice.
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>
09-02-2004, 08:43 PM
#9
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Thanks DougW. Checked out your LED turn signal add ons on you site, Nice.
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>
09-02-2004, 08:43 PM
#10
Guest
Posts: n/a
Re: 96 GC suddenly lost AC cooling
Thanks DougW. Checked out your LED turn signal add ons on you site, Nice.
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>
System is manual AC. Low side pressure is 65 when engine is off. Cycles from
10 - 45 w/AC on. Clutch kicks in when pressure hits 45 then as it begins to
drop clutch stops. This is all of about 5 -7 seconds.
Fan pushes air well and heat settings work fine.
Hikers w/Humid Jeep
"DougW" <post.replies@invalid.address> wrote in message
news:xBQYc.71010$wo.44481@okepread06...
> Hikers did pass the time by typing:
> > Lost cooling in my 6cyl '96 GC without warning this weekend. Fan works,
> > condenser turns on and off, low pressure line is very cold and
condensation
> > forms on the line. Air coming thru vents might have a higher humidity
level
> > when the AC is turned on than when it is off.
> > Towed a 2500lb trailer last week for the first time, 400 miles thru the
> > hills of Pennsylvania and AC was working fine.
> > Any ideas? just turned 100K miles last week.
>
> If the compressor cycles properly my first thought is vac leak.
> Clicking on/off real rapididly means you could be low on 134a.
>
> Is it an auto or manual AC system? The auto has diagnositcs and
> doesn't use vac for much. The maunal uses vac for almost everything
> except the blend air door.
>
> Does it blow well? If not you might have mold buildup clogging the coil.
>
> I don't have the specifics for the 96 but it should be similar in layout
> to the 93.
>
> --
> -- DougW -- 93 ZJ 4.0 http://members.***.net/wilsond
> HESCO Supercharger - 300W IASCA Stereo - Edelbrock IAS Shocks
> Gibson Exhaust - rear DCpower - custom gauge install - Stillen Rotors
> Banks Header - and BEER, in the fridge!
>
>