CJ horn and wiper fluid motor info needed
 

My CJ does not have a horn or a wiper fluid reservior. I went out an picked
that stuff up from a junk yard the other day. I haven't had time to get
into this much, but I do know that I don't see any wires that look like they
don't have anywhere to go. Does anyone know the color(s) and what side of
the engine compartment these wires are and where this stuff used to bolt to?
Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
even list a horn in the wire diagram.
Thanks!
Allen
83 JC7

Re: CJ horn and wiper fluid motor info needed
 

Washer pump power wire is yellow and I think the horn is a red with a
white stripe that should be on the top of the drivers side fender.

The Haynes manual has a decent wiring diagram.

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's

Allen wrote:
>
> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7

Re: CJ horn and wiper fluid motor info needed
 

Washer pump power wire is yellow and I think the horn is a red with a
white stripe that should be on the top of the drivers side fender.

The Haynes manual has a decent wiring diagram.

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's

Allen wrote:
>
> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7

Re: CJ horn and wiper fluid motor info needed
 

Washer pump power wire is yellow and I think the horn is a red with a
white stripe that should be on the top of the drivers side fender.

The Haynes manual has a decent wiring diagram.

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's

Allen wrote:
>
> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7

Re: CJ horn and wiper fluid motor info needed
 

Both wires are in the harness that starts at the bulkhead connector at the
firewall then runs along the top of the left inner fender and into the
grill. The washer pump wire is probably Yellow/White and is near the
ignition module bolted to the lower edge of the fender well. The washer
tank bolts to three holes just above that module. The horn bolts to the
fender very close to the grill, the horn wire is probably Red/Black. Both
get full (+) voltage when the appropriate switch is closed.

You may need to fashion a new ground lead for the washer pump. The OEM
was a wire riveted to the pump housing and usually rots away.


On Sun, 18 Jan 2004, Allen wrote:

> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7
>
>
>

Re: CJ horn and wiper fluid motor info needed
 

Both wires are in the harness that starts at the bulkhead connector at the
firewall then runs along the top of the left inner fender and into the
grill. The washer pump wire is probably Yellow/White and is near the
ignition module bolted to the lower edge of the fender well. The washer
tank bolts to three holes just above that module. The horn bolts to the
fender very close to the grill, the horn wire is probably Red/Black. Both
get full (+) voltage when the appropriate switch is closed.

You may need to fashion a new ground lead for the washer pump. The OEM
was a wire riveted to the pump housing and usually rots away.


On Sun, 18 Jan 2004, Allen wrote:

> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7
>
>
>

Re: CJ horn and wiper fluid motor info needed
 

Both wires are in the harness that starts at the bulkhead connector at the
firewall then runs along the top of the left inner fender and into the
grill. The washer pump wire is probably Yellow/White and is near the
ignition module bolted to the lower edge of the fender well. The washer
tank bolts to three holes just above that module. The horn bolts to the
fender very close to the grill, the horn wire is probably Red/Black. Both
get full (+) voltage when the appropriate switch is closed.

You may need to fashion a new ground lead for the washer pump. The OEM
was a wire riveted to the pump housing and usually rots away.


On Sun, 18 Jan 2004, Allen wrote:

> My CJ does not have a horn or a wiper fluid reservior. I went out an picked
> that stuff up from a junk yard the other day. I haven't had time to get
> into this much, but I do know that I don't see any wires that look like they
> don't have anywhere to go. Does anyone know the color(s) and what side of
> the engine compartment these wires are and where this stuff used to bolt to?
> Where do the wires run *from* in the engine bay? My Chiltons sucks..doens't
> even list a horn in the wire diagram.
> Thanks!
> Allen
> 83 JC7
>
>
>