94 Wrangler Sahara grinds during shifting
 

I replaced the clutch master and slave still grinds not sure where to
go from here.

Re: 94 Wrangler Sahara grinds during shifting
 

I will fire up the ol crystal ball here....

Maybe you are describing the throw out bearing going bad? If so I would
live with it and just shift fast until I needed a clutch.

But, if it grinds when going into gear, then more likely you have not
enough of or the wrong fluid in there. The syncros fail if you use the
wrong stuff.

Or if you cross water, you could have a tranny full of water seeing as
Jeep doesn't put a high water vent on the tranny, only the diffs and
t-case.

Or if you have been mud running, maybe the tranny is full of mud via the
same vent. (have seen that several times, looked like diarrhea coming
out the drain)

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
(More Off Road album links at bottom of the view page)

Brad wrote:
>
> I replaced the clutch master and slave still grinds not sure where to
> go from here.

Re: 94 Wrangler Sahara grinds during shifting
 

I will fire up the ol crystal ball here....

Maybe you are describing the throw out bearing going bad? If so I would
live with it and just shift fast until I needed a clutch.

But, if it grinds when going into gear, then more likely you have not
enough of or the wrong fluid in there. The syncros fail if you use the
wrong stuff.

Or if you cross water, you could have a tranny full of water seeing as
Jeep doesn't put a high water vent on the tranny, only the diffs and
t-case.

Or if you have been mud running, maybe the tranny is full of mud via the
same vent. (have seen that several times, looked like diarrhea coming
out the drain)

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
(More Off Road album links at bottom of the view page)

Brad wrote:
>
> I replaced the clutch master and slave still grinds not sure where to
> go from here.

Re: 94 Wrangler Sahara grinds during shifting
 

I will fire up the ol crystal ball here....

Maybe you are describing the throw out bearing going bad? If so I would
live with it and just shift fast until I needed a clutch.

But, if it grinds when going into gear, then more likely you have not
enough of or the wrong fluid in there. The syncros fail if you use the
wrong stuff.

Or if you cross water, you could have a tranny full of water seeing as
Jeep doesn't put a high water vent on the tranny, only the diffs and
t-case.

Or if you have been mud running, maybe the tranny is full of mud via the
same vent. (have seen that several times, looked like diarrhea coming
out the drain)

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's
Canadian Off Road Trips Photos: Non members can still view!
Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
(More Off Road album links at bottom of the view page)

Brad wrote:
>
> I replaced the clutch master and slave still grinds not sure where to
> go from here.

Re: 94 Wrangler Sahara grinds during shifting
 

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>

Re: 94 Wrangler Sahara grinds during shifting
 

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>

Re: 94 Wrangler Sahara grinds during shifting
 

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>

Re: 94 Wrangler Sahara grinds during shifting
 

I will also contribute to check the fluid shortly after driving. I had a
problem where I checked my fluid cold and it looked fine, but the tranny
developed some grinding, so I checked it again but hot. It was that nasty
watery brown. I can only figure the water settled to the borrom after
sitting for a while.

Matt

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>

Re: 94 Wrangler Sahara grinds during shifting
 

I will also contribute to check the fluid shortly after driving. I had a
problem where I checked my fluid cold and it looked fine, but the tranny
developed some grinding, so I checked it again but hot. It was that nasty
watery brown. I can only figure the water settled to the borrom after
sitting for a while.

Matt

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>

Re: 94 Wrangler Sahara grinds during shifting
 

I will also contribute to check the fluid shortly after driving. I had a
problem where I checked my fluid cold and it looked fine, but the tranny
developed some grinding, so I checked it again but hot. It was that nasty
watery brown. I can only figure the water settled to the borrom after
sitting for a while.

Matt

"Mike Romain" <romainm@sympatico.ca> wrote in message
news:452522F1.B11102E2@sympatico.ca...
>I will fire up the ol crystal ball here....
>
> Maybe you are describing the throw out bearing going bad? If so I would
> live with it and just shift fast until I needed a clutch.
>
> But, if it grinds when going into gear, then more likely you have not
> enough of or the wrong fluid in there. The syncros fail if you use the
> wrong stuff.
>
> Or if you cross water, you could have a tranny full of water seeing as
> Jeep doesn't put a high water vent on the tranny, only the diffs and
> t-case.
>
> Or if you have been mud running, maybe the tranny is full of mud via the
> same vent. (have seen that several times, looked like diarrhea coming
> out the drain)
>
> Mike
> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
> 88 Cherokee 235 BFG AT's
> Canadian Off Road Trips Photos: Non members can still view!
> Jan/06 http://www.imagestation.com/album/pi...?id=2115147590
> (More Off Road album links at bottom of the view page)
>